Hyundai i-30: Button Engine Start System / ESCL(Electronic Steering Column Lock)

Hyundai i30 (PD) 2018-2025 Service Manual / Body Electrical System / Button Engine Start System / ESCL(Electronic Steering Column Lock)

Components and components location
Component

Repair procedures
Removal
1.
Disconnect the negative(-) battery terminal.
2.
Remove the crash pad lower panel.
(Refer to Body - "Crash Pad Lower Panel")
3.
Remove the steering column upper and lower shrouds.
(Refer to Body - "Steering Column Shroud Panel")
4.
Disconnect the electronic steering column lock connector (A).

5.
Remove the electronic steering column lock.
(Refer to Steering System - "Steering Column and Shaft")

Installation
1.
Install the electronic steering column lock.
  
Do not reuse the shear bolts.
When installing the new shear bolts to the electronic steering column lock, tighten the shear bolts until its head is cut off.
Tightening torque :
7.0 - 13.0 N.m (0.7 - 1.3 kgf.m, 5.0 - 9.4 lb.ft)
2.
Install the steering column.
3.
Install the crash pad lower panel.

    Start/Stop Button

    Components and components location Component Repair procedures Removal 1. Disconnect the negative(-) battery terminal...

    Ignition Switch Assembly

    ..

    Other information:

    Hyundai i30 (PD) 2018-2025 Service Manual: Mass Air Flow Sensor (MAFS)


    Description and operation Description MAFS uses a hot-film type sensing element to measure the mass of intake air entering the engine, and send the signal to ECM. A large amount of intake air represents acceleration or high load conditions while a small amount of intake air represents deceleration or idle...

    Hyundai i30 (PD) 2018-2025 Owner's Manual: Dual clutch transmission


    Dual clutch transmission operation The dual clutch transmission has seven forward speeds and one reverse speed. The individual speeds are selected automatically when the shift lever is in the D (Drive) position. The dual clutch transmission can be thought of as an automatically shifting manual transmission...

    Categories

    Air bag - supplemental restraint system

    Hyundai i30. Air bag - supplemental restraint system

    1. Driver’s front air bag
    2. Passenger’s front air bag
    3. Side air bag*
    4. Curtain air bag*
    5. Knee air bag*
    6. Front passenger air bag ON/OFF switch

    read more


     
    Copyright © 2025 www.hi30.net