Hyundai i30 (PD) 2018-2025 Service Manual
Hyundai i30 (PD) 2018-2025 Service Manual
- General Information
- General Tightening Torque Table
- Important Safety Notice
- Identification Numbers
- Warning and Caution Labels
- Lift and Support Points
- Towing
- Basic Service Symbols
- General Service Information
- Engine Mechanical System
- Specifications
- Repair procedures
- Troubleshooting
- Special service tools
- Engine and Transaxle Assembly
- Drive Belt System
- Timing System
- Cylinder Head Assembly
- Cylinder Block
- Cooling System
- Lubrication System
- Intake and Exhaust System
- Engine Electrical System
- Emission Control System
- Description and operation
- Specifications
- Troubleshooting
- Schematic diagrams
- Components and components location
- Crankcase Emission Control System
- Evaporative Emission Control System
- Exhaust Emission Control System
- Engine Control / Fuel System
- Specifications
- Special service tools
- Troubleshooting
- Engine Control System
- ISG (Idle Stop & Go) System
- Fuel Delivery System
- Clutch System
- Specifications
- Special service tools
- Troubleshooting
- Clutch Cover And Disc
- Ignition Lock Switch
- Clutch Switch
- Clutch Pedal
- Clutch Tube
- Clutch Regulator
- Clutch Master Cylinder
- Concentric Slave Cylinder Assembly
- DCT(Dual Clutch Transmission) System
- Specifications
- Special service tools
- Troubleshooting
- Dual Clutch Transmission Assembly
- Dual Clutch Transmission Control System
- Dual Clutch System
- Driveshaft and axle
- General Information
- Front Axle Assembly. Front Hub / Knuckle
- Driveshaft Assembly
- Rear Axle Assembly. Rear Hub - Carrier
- Suspension System (NON-ECS)
- Specifications
- Special service tools
- Troubleshooting
- Front Suspension System
- Rear Suspension System
- Tires/Wheels
- Tire Pressure Monitoring System
- Suspension System (NON-ECS)
- Steering System
- Restraint
- General information
- Specifications
- Special service tools
- General safety information and caution
- Description and operation
- Repair procedures
- Components and components location
- SRSCM
- Airbag Module
- Seat Belt Pretensioner
- Brake System
- Specifications
- Special service tools
- Troubleshooting
- Brake System
- Parking Brake System
- ABS (Anti-Lock Brake System)
- ESP (Electronic Stability Program) System
- Autonomous Emergency Braking (AEB) System
- Body (Interior and Exterior)
- Specifications
- Special service tools
- Troubleshooting
- Fender
- Hood
- Tail Gate
- Fuel Filler Door
- Front Door
- Rear Door
- Body Side Molding
- Panorama sunroof
- Mirror
- Cowl Top Cover
- Floor Console
- Crash Pad
- Roof Trim
- Interior Trim
- Trunk Trim
- Windshield Glass
- Floor Carpet
- Front Bumper
- Rear Bumper
- Front Seat
- Rear Seat
- Front Seat Belt
- Rear Seat Belt
- Body Electrical System
- General Information
- Horn
- Multifunction Switch
- Audio
- AVN System
- Emergency Call System
- Smart Key System
- Keyless Entry And Burglar Alarm
- BCM (Body Control Module)
- IMS(Integrated Memory System)
- Seat Electrical
- Fuel Filler Door
- Fuses And Relays
- Indicators And Gauges
- Power Door Locks
- Power Door Mirrors
- Power Windows
- Rear Glass Defogger
- Windshield Wiper/Washer
- Rear Wiper/Washer
- Electro Chromic Inside Rear View Mirror
- Panorama Sunroof
- Lighting System
- Auto Lighting Control System
- Auto Head Lamp Leveling Device
- Immobilizer System
- Button Engine Start System
- Ignition Switch Assembly
- Wireless Power Charger System
- Heating, Ventilation and Air Conditioning
- Advanced Driver Assistance System (ADAS)
Fuel label
Petrol engine
The fuel label is attached on the fuel
filler door.
A. Octane rating of unleaded petrol
1) RON/ROZ : Research Octane
Number
2) (R+M)/2, AKI : Anti Knock Index
B...
Other information:
Hyundai i30 (PD) 2018-2025 Owner's Manual: Wheel alignment and tyre balance
The wheels on your vehicle were aligned and balanced carefully at the factory to give you the longest tyre life and best overall performance. In most cases, you will not need to have your wheels aligned again. However, if you notice unusual tyre wear or your vehicle pulling one way or the other, the alignment may need to be reset...
Hyundai i30 (PD) 2018-2025 Service Manual: Troubleshooting
Troubleshooting Symptom Passible Cause Remedy (Refer to page) Water leaks from panorama sunroof Deteriorated roof lid weatherstrip Replace Excessive roof lid-to-body clearance and improperly fitted weatherstrip Adjust Wind noise around Panorama sunroof Loose or deformed deflector, gaps in body work Retighten adjust or replace Noise created by moving panorama sunroof lid Foreign particles lodged in guide rail Check drive cable and guide rails for foreign particles Loose guide rails and lid Retighten Motor runs but sunroof does not move or moves only partially Foreign particles lodged in guide rail Adjust or replace Incorrect engagement of motor pinion with drive cable Decrease in motor's clutch slipping force Increased sunroof sliding resistance or interference of sunroof with drive cables, weatherstrip, etc...
Categories
- Manuals Home
- 3rd Generation i30 Owners Manual
- 3rd Generation i30 Service Manual
- Battery replacement
- Tyre pressure monitoring system
- Drive mode integrated control system
- New on site
- Most important about car
Panorama sunroof
If your vehicle is equipped with a sunroof, you can slide or tilt your sunroof with the sunroof control lever located on the overhead console.
The ignition switch must be in the ON position before you can open or close the sunroof.
The sunroof can be operated for approximately 30 seconds after the ignition key is removed or turned to the ACC or LOCK(or OFF) position. However, if the front door is opened, the sunroof cannot be operated even within 30 seconds.
Copyright © 2025 www.hi30.net