Hyundai i-30: Panorama sunroof / Movable Glass

Hyundai i30 (PD) 2018-2025 Service Manual / Body (Interior and Exterior) / Panorama sunroof / Movable Glass

Repair procedures
Replacement
1.
Open movable glass completely pressing panorama sunroof switch.
2.
Remove the slide folding cover (A).

3.
Close movable glass completely pressing panorama sunroof switch .
4.
Loosen screws mounted on the glass using star wrench (T25) then remove movable glass (A).
  
Be careful not to damage screws.

5.
To install, reverse the removal procedure.
  
Carry out considerable step adjustment after exchanging movable glass.
When movable glass is installed tilt lever should be inserted first and be careful that tilt lever shoe should not be damaged by rear rail interference.

    Repair procedures

    Adjustment Inspect Glass Alignment 1. Perform considerable step alignment after replacing movable glass (A). A - A B- B C -C D - D 2...

    Front Glass

    Repair procedures Removal    • In order to remove the front glass, use the tools shown in the following figure: [Tooling Diagram] ① Square wire ② Insert-type wire grip • Insert and affix square wire ① into the insert hole of the wire grip ②...

    Other information:

    Hyundai i30 (PD) 2018-2025 Service Manual: Troubleshooting


    Troubleshooting Symptom Possible cause Remedy Hard steering Improper front wheel alignment Excessive turning resistance of lower arm ball joint Low tire pressure No power assist Correct Replace Adjust Repair and replace Poor return of steering wheel to center Improper front wheel alignment Correct Poor or rough ride Improper front wheel alignment Malfunctioning shock absorber Broken or worn stabilizer Broken or worn coil spring Worn lower arm bushing Correct Repair or replace Replace Replace Replace the lower arm assembly Abnormal tire wear Improper front wheel alignment Improper tire pressure Malfunctioning shock absorber Correct Adjust or replace Replace Wandering Improper front wheel alignment Poor turning resistance of lower arm ball joint Loose or worn lower arm bushing Correct Repair Retighten or replace Vehicle pulls to one side Improper front wheel alignment Excessive turning resistance of lower arm ball joint Broken or worn coil spring Bent lower arm Correct Replace Replace Repair Steering wheel shimmy Improper front wheel alignment Poor turning resistance of lower arm ball joint Broken or worn stabilizer Worn lower arm bushing Malfunctioning shock absorber Broken or worn coil spring Correct Replace Replace Replace Replace Replace Bottoming Broken or worn coil spring Malfunctioning shock absorber Replace Replace Wheel /tire noise, vibration and harshness concerns are directly related to vehicle speed and are not generally affected by acceleration, coasting or decelerating...

    Hyundai i30 (PD) 2018-2025 Owner's Manual: Steering wheel


    Electric power steering (EPS) The system assists you with steering the vehicle. If the engine is off or if the power steering system becomes inoperative, the vehicle may still be steered, but it will require increased steering effort. Also, the steering effort becomes heavier as the vehicle’s speed increases and becomes lighter as the vehicle’s speed decreases for better control of the steering wheel...

    Categories

    Power windows

    Hyundai i30. Power windows

    (1) Driver’s door power window switch
    (2) Front passenger’s door power window switch
    (3) Rear door (right) power window switch
    (4) Rear door (left) power window switch
    (5) Window opening and closing
    (6) Automatic power window
    (7) Power window lock switch

    read more


     
    Copyright © 2025 www.hi30.net